Evaluation of Bioethanol Production from Enset (<i>Ensete ventricosum</i> (Welw.) Cheesman) Processing Waste and Leaf Using <i>Saccharomyces cerevisiae</i>

Desta Lamore Erebo

doi:doi:10.11648/j.be.20210502.13

| Peer-Reviewed

Evaluation of Bioethanol Production from Enset (Ensete ventricosum (Welw.) Cheesman) Processing Waste and Leaf Using Saccharomyces cerevisiae

Desta Lamore Erebo

Published in Bioprocess Engineering (Volume 5, Issue 2)

Received: 10 September 2021 Accepted: 19 October 2021 Published: 5 November 2021

Views: Downloads:

Download PDF

Share This Article

Twitter
Linked In
Facebook

Abstract

The depletion of fossil fuel reserves and the increasing awareness of greenhouse gas emissions act as the primary driving force for finding alternative renewable energy sources, especially those derived from biomass. This study was conducted with the objective of bio-ethanol production from non- edible plant biomass, Enset [Ensete ventricosum (Welw.) Cheesman] processing waste and leaves in batch fermentation using yeas (S. cerevisiae). Forty grams of acid pre-treated or untreated ensete processing waste and leaves were incubated with 1% of yeast under three different temperature (26°C, 30°C and 40°C) treatments and allowed to ferment over 16 days. Yeast cell density, total reducing sugars and percent of ethanol was measured at 4 days interval spectrophotometrically beginning from the incubation period. Results showed that all measured parameters subsequently decrease with increasing days of fermentation in both acid pre-treated and untreated substrates. Acid pre-treated substrates resulted in higher amounts of cell density, total reducing sugars and bio-ethanol than untreated substrates. Among the different temperatures, 30°C produced more bio-ethanol than others throughout the fermentation periods, and the result was in agreement with cell density and total sugars measured. In conclusion, this study showed that Enset processing waste and leaves can be used as a feedstock for bio-ethanol production and the yield can be increased with acid pre-treatment and incubation under 30°C temperature.

Published in	Bioprocess Engineering (Volume 5, Issue 2)
DOI	10.11648/j.be.20210502.13
Page(s)	49-55
Creative Commons	This is an Open Access article, distributed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution and reproduction in any medium or format, provided the original work is properly cited.
Copyright	Copyright © The Author(s), 2021. Published by Science Publishing Group

Keywords

Batch Fermentation, Cell Biomass, Bio-ethanol, Enset Processing Waste, Ensete Leaf, Reducing Sugar

References

[1]	Abouzeid and A. Reddy. 1986. "Direct fermentation of potato starch to ethanol by Co-Culture of Aspergillus Niger and Saccharomyces cerviciae," J. appl. microbiol. Vol. 52. Pp. 1055-1059.
[2]	Akin-Osaniye, B. C., Nzelibe, H. C., Agbaji, A. S. 2005. Production of ethanol from carica papaya (paw paw) agro waste effect of Saccharification and different treatments on the ethanol yield. Afr. S. Biotechnology., 4 (7): 657-659.
[3]	Balat, M., Balat, H. O. 2008. Progress in bioethanol processing. Prog Energy Combust Sci; 34: 551e73.
[4]	Bennett, C. 1971. Spectrophotometric acid dichromate method for the determination of ethyl alcohol. Am. J. Med. Technol., 37: 217-220.
[5]	Bordwell, R. G. and K. M. Wellman. 1962. A rapid test to distinguish tertiary from primary and secondary alcohols. J. Chem. Ed. 39: 308-310.
[6]	Brochure. 2007. Produced by the European Biomass industry Association which was supported by the European commission under 6^th program (FP6). Retrieved on March, 23 from: http://www.europea.eu/rapid/presreleasedaction.
[7]	Brooks, A. A., 2008. Ethanol production potential of local yeast strains Isolated from ripe banana peels, African journal of Biotechnology, 7 (20): 3749-3752.
[8]	Caputi, AJ., Ueda, M. and Brown, T. 1968. Spectrophotometric determination of ethanol in wine. American Journal of Enology Viticulture 19: 160- 165.
[9]	Chandel, A. K., Felipe A. F. A., Priscila V. A., Milessi, T. S. S., da Silvio S. S. and Maria G. 2012. Dilute Acid Hydrolysis of Agro-Residues for the Depolymerization of Hemicellulose: State-of-the-Art. Springer-Verlag Berlin Heidelberg DOI: 10.1007/978- 3-642-31887-02, pp 39-61.
[10]	Demirbas, A. 2009. Biofuels securing the planet’s future energy needs. Energy Conversion and Management, 50 (9): 2239-2249.
[11]	Dhopeshwarker, R., Javadav, U., R., D’ Souza, L. Jayaprakash, D. 2001. Continuous ethanol production by fermentation of waste banana peels using flocculating yeast. Indian journal of chemical Technology 40: B25.
[12]	Esteghlalian, A., Hahimoto, A. G., Fenske, J. J., Penner, M. H. 1997. Modeling and optimization of the dilute sulphuric acid pretreatment of corn stove, polar and switch grass. Bioresource Technol. 59: 129-136.
[13]	Galbe, M., Zacchi, G. 2002. A review of the production of ethanol from softwood. Applied Microbiology and Biotechnology; 59: 618–28.
[14]	Hossana Town Finance and Economic Development Office, 2018.
[15]	Humphrey, C. N. & Caritas, A. O. 2007. Optimization of Ethanol Production from Garcinia kola (bitter kola) pulp agro waste. Africa Journal of Biotechnology, 6 (17): pp 2033-2037.
[16]	Junchen, L., Muhammad, I. & Lin, F. 2012. Bioconversion of agricultural waste to ethanol: A potential source of energy. Achives Des Sciences 65 (12) pp 626-642.
[17]	Maggio, C. & Cacciola, G. 2012. When will oil, natural gas, and coal peak? Fuel.
[18]	Miller, G. L. 1959. Use of dinitrosalicylic acid reagent for determination of reducing sugar. Analytical Chemistry, Vol. 31, No. 3, p. 426-428, ISSN 0003-2700.
[19]	Nelson, N. J., Journal of Biological Chemistry. 1944. 153, 375.
[20]	Sadasivam, M. And Manickam, A. 1996. Biochemical methods, New age international Limited Publishers, New Delhi, pp. 1–235.
[21]	Sharma-shivappa, R. R., Boyette, M. D., and Osborne, J. 2007. A comparision of chemical pretreatment methods for improving Saccharification of cotton stalks. Bioresource, Technol., 98, 300-11.
[22]	Somogyi, M. 1945. Journal of Biological Chemistry, 160, 61.
[23]	Summer, J. B. and G. F. Somers. 2004. Laboratory Experiments in Biological Chemistry. Academic Press, Inc., New York.
[24]	Swine, M. R., S. Kar, A. K. Sahoo, R. C. Ray. 2007. Ethanol fermentation of mahula (Madhuca latifolial.) flowers using free and immobilized yeast Saccharomyces cerevisiae. Microbiolology Research, 162: 93-98.
[25]	Taye Bezuneh. 1984. Evaluation of some Ensete ventricosum clones for food yield with emphasis on the effect of length of fermentation on carbohydrate and calcium content. Tropical Agriculture, 61 (2): 111-116.
[26]	Wondimu Abrham, Gebre-Mariam Tsige. 2010. Preparation and characterization of pregelatinized enset starch and evaluation of its use as binder and disintegrant in tablet formulations. MSc. Thesis, School of Graduate Study, Addis Ababa University.
[27]	Yoswathana, N., Phuriphipat, P. 2010. Bioethanol Production from Rice Straw. Energy Res J 11: 26-31.
[28]	Yu, J., Corripio, A. B., Harrison, O. P., Copeland, R. J. 2003. Analysis of the sorbent energy transfer system (SETS) for power generation and CO₂ capture. Adv Environ; 7: 335–45.

Cite This Article

Plain Text BibTeX RIS

APA Style

Desta Lamore Erebo. (2021). Evaluation of Bioethanol Production from Enset (Ensete ventricosum (Welw.) Cheesman) Processing Waste and Leaf Using Saccharomyces cerevisiae. Bioprocess Engineering, 5(2), 49-55. https://doi.org/10.11648/j.be.20210502.13

Copy | Download

ACS Style

Desta Lamore Erebo. Evaluation of Bioethanol Production from Enset (Ensete ventricosum (Welw.) Cheesman) Processing Waste and Leaf Using Saccharomyces cerevisiae. Bioprocess Eng. 2021, 5(2), 49-55. doi: 10.11648/j.be.20210502.13

Copy | Download

AMA Style

Desta Lamore Erebo. Evaluation of Bioethanol Production from Enset (Ensete ventricosum (Welw.) Cheesman) Processing Waste and Leaf Using Saccharomyces cerevisiae. Bioprocess Eng. 2021;5(2):49-55. doi: 10.11648/j.be.20210502.13

Copy | Download

@article{10.11648/j.be.20210502.13,
  author = {Desta Lamore Erebo},
  title = {Evaluation of Bioethanol Production from Enset (Ensete ventricosum (Welw.) Cheesman) Processing Waste and Leaf Using Saccharomyces cerevisiae},
  journal = {Bioprocess Engineering},
  volume = {5},
  number = {2},
  pages = {49-55},
  doi = {10.11648/j.be.20210502.13},
  url = {https://doi.org/10.11648/j.be.20210502.13},
  eprint = {https://article.sciencepublishinggroup.com/pdf/10.11648.j.be.20210502.13},
  abstract = {The depletion of fossil fuel reserves and the increasing awareness of greenhouse gas emissions act as the primary driving force for finding alternative renewable energy sources, especially those derived from biomass. This study was conducted with the objective of bio-ethanol production from non- edible plant biomass, Enset [Ensete ventricosum (Welw.) Cheesman] processing waste and leaves in batch fermentation using yeas (S. cerevisiae). Forty grams of acid pre-treated or untreated ensete processing waste and leaves were incubated with 1% of yeast under three different temperature (26°C, 30°C and 40°C) treatments and allowed to ferment over 16 days. Yeast cell density, total reducing sugars and percent of ethanol was measured at 4 days interval spectrophotometrically beginning from the incubation period. Results showed that all measured parameters subsequently decrease with increasing days of fermentation in both acid pre-treated and untreated substrates. Acid pre-treated substrates resulted in higher amounts of cell density, total reducing sugars and bio-ethanol than untreated substrates. Among the different temperatures, 30°C produced more bio-ethanol than others throughout the fermentation periods, and the result was in agreement with cell density and total sugars measured. In conclusion, this study showed that Enset processing waste and leaves can be used as a feedstock for bio-ethanol production and the yield can be increased with acid pre-treatment and incubation under 30°C temperature.},
 year = {2021}
}

Copy | Download

TY  - JOUR
T1  - Evaluation of Bioethanol Production from Enset (Ensete ventricosum (Welw.) Cheesman) Processing Waste and Leaf Using Saccharomyces cerevisiae
AU  - Desta Lamore Erebo
Y1  - 2021/11/05
PY  - 2021
N1  - https://doi.org/10.11648/j.be.20210502.13
DO  - 10.11648/j.be.20210502.13
T2  - Bioprocess Engineering
JF  - Bioprocess Engineering
JO  - Bioprocess Engineering
SP  - 49
EP  - 55
PB  - Science Publishing Group
SN  - 2578-8701
UR  - https://doi.org/10.11648/j.be.20210502.13
AB  - The depletion of fossil fuel reserves and the increasing awareness of greenhouse gas emissions act as the primary driving force for finding alternative renewable energy sources, especially those derived from biomass. This study was conducted with the objective of bio-ethanol production from non- edible plant biomass, Enset [Ensete ventricosum (Welw.) Cheesman] processing waste and leaves in batch fermentation using yeas (S. cerevisiae). Forty grams of acid pre-treated or untreated ensete processing waste and leaves were incubated with 1% of yeast under three different temperature (26°C, 30°C and 40°C) treatments and allowed to ferment over 16 days. Yeast cell density, total reducing sugars and percent of ethanol was measured at 4 days interval spectrophotometrically beginning from the incubation period. Results showed that all measured parameters subsequently decrease with increasing days of fermentation in both acid pre-treated and untreated substrates. Acid pre-treated substrates resulted in higher amounts of cell density, total reducing sugars and bio-ethanol than untreated substrates. Among the different temperatures, 30°C produced more bio-ethanol than others throughout the fermentation periods, and the result was in agreement with cell density and total sugars measured. In conclusion, this study showed that Enset processing waste and leaves can be used as a feedstock for bio-ethanol production and the yield can be increased with acid pre-treatment and incubation under 30°C temperature.
VL  - 5
IS  - 2
ER  -

Copy | Download

Author Information

Desta Lamore Erebo

Biotechnology Department, College of Natural and Computational Sciences, Wachemo University, Hossana, Ethiopia

Download PDF

Sections

Plain Text BibTeX RIS

APA Style

Desta Lamore Erebo. (2021). Evaluation of Bioethanol Production from Enset (Ensete ventricosum (Welw.) Cheesman) Processing Waste and Leaf Using Saccharomyces cerevisiae. Bioprocess Engineering, 5(2), 49-55. https://doi.org/10.11648/j.be.20210502.13

Copy | Download

ACS Style

Desta Lamore Erebo. Evaluation of Bioethanol Production from Enset (Ensete ventricosum (Welw.) Cheesman) Processing Waste and Leaf Using Saccharomyces cerevisiae. Bioprocess Eng. 2021, 5(2), 49-55. doi: 10.11648/j.be.20210502.13

Copy | Download

AMA Style

Desta Lamore Erebo. Evaluation of Bioethanol Production from Enset (Ensete ventricosum (Welw.) Cheesman) Processing Waste and Leaf Using Saccharomyces cerevisiae. Bioprocess Eng. 2021;5(2):49-55. doi: 10.11648/j.be.20210502.13

Copy | Download

@article{10.11648/j.be.20210502.13,
  author = {Desta Lamore Erebo},
  title = {Evaluation of Bioethanol Production from Enset (Ensete ventricosum (Welw.) Cheesman) Processing Waste and Leaf Using Saccharomyces cerevisiae},
  journal = {Bioprocess Engineering},
  volume = {5},
  number = {2},
  pages = {49-55},
  doi = {10.11648/j.be.20210502.13},
  url = {https://doi.org/10.11648/j.be.20210502.13},
  eprint = {https://article.sciencepublishinggroup.com/pdf/10.11648.j.be.20210502.13},
  abstract = {The depletion of fossil fuel reserves and the increasing awareness of greenhouse gas emissions act as the primary driving force for finding alternative renewable energy sources, especially those derived from biomass. This study was conducted with the objective of bio-ethanol production from non- edible plant biomass, Enset [Ensete ventricosum (Welw.) Cheesman] processing waste and leaves in batch fermentation using yeas (S. cerevisiae). Forty grams of acid pre-treated or untreated ensete processing waste and leaves were incubated with 1% of yeast under three different temperature (26°C, 30°C and 40°C) treatments and allowed to ferment over 16 days. Yeast cell density, total reducing sugars and percent of ethanol was measured at 4 days interval spectrophotometrically beginning from the incubation period. Results showed that all measured parameters subsequently decrease with increasing days of fermentation in both acid pre-treated and untreated substrates. Acid pre-treated substrates resulted in higher amounts of cell density, total reducing sugars and bio-ethanol than untreated substrates. Among the different temperatures, 30°C produced more bio-ethanol than others throughout the fermentation periods, and the result was in agreement with cell density and total sugars measured. In conclusion, this study showed that Enset processing waste and leaves can be used as a feedstock for bio-ethanol production and the yield can be increased with acid pre-treatment and incubation under 30°C temperature.},
 year = {2021}
}

Copy | Download

TY  - JOUR
T1  - Evaluation of Bioethanol Production from Enset (Ensete ventricosum (Welw.) Cheesman) Processing Waste and Leaf Using Saccharomyces cerevisiae
AU  - Desta Lamore Erebo
Y1  - 2021/11/05
PY  - 2021
N1  - https://doi.org/10.11648/j.be.20210502.13
DO  - 10.11648/j.be.20210502.13
T2  - Bioprocess Engineering
JF  - Bioprocess Engineering
JO  - Bioprocess Engineering
SP  - 49
EP  - 55
PB  - Science Publishing Group
SN  - 2578-8701
UR  - https://doi.org/10.11648/j.be.20210502.13
AB  - The depletion of fossil fuel reserves and the increasing awareness of greenhouse gas emissions act as the primary driving force for finding alternative renewable energy sources, especially those derived from biomass. This study was conducted with the objective of bio-ethanol production from non- edible plant biomass, Enset [Ensete ventricosum (Welw.) Cheesman] processing waste and leaves in batch fermentation using yeas (S. cerevisiae). Forty grams of acid pre-treated or untreated ensete processing waste and leaves were incubated with 1% of yeast under three different temperature (26°C, 30°C and 40°C) treatments and allowed to ferment over 16 days. Yeast cell density, total reducing sugars and percent of ethanol was measured at 4 days interval spectrophotometrically beginning from the incubation period. Results showed that all measured parameters subsequently decrease with increasing days of fermentation in both acid pre-treated and untreated substrates. Acid pre-treated substrates resulted in higher amounts of cell density, total reducing sugars and bio-ethanol than untreated substrates. Among the different temperatures, 30°C produced more bio-ethanol than others throughout the fermentation periods, and the result was in agreement with cell density and total sugars measured. In conclusion, this study showed that Enset processing waste and leaves can be used as a feedstock for bio-ethanol production and the yield can be increased with acid pre-treatment and incubation under 30°C temperature.
VL  - 5
IS  - 2
ER  -

Copy | Download